American Sportworks UTV Operations Instructions download pdf (Page 20)

Transaxle Oil Change

Warm oil drains quickly and completely Therefore, drain

usedtransaxleoilwhiletransaxlehousingisstillwarmas

follows:

    

1 Parkvehicleonalevelsurface,setparkbrake,turnoff

 ignitionswitch,andremoveswitchkey

2 Placeasuitablecontainerbelowthetransfercaseto

 catchusedoilRemovellcapanddrainplug

3 Allowusedoiltodraincompletelyandthenreinstall

 drainplugandtightenitsecurely

4 Disposeofusedtransaxlecaseoilinamannerthatis

 compatiblewiththeenvironmentDonotthrowusedoil

 inthetrash,pouritontheground,ordownadrain

5 Filltransaxlehousingwith20ozSAE30Woil

6 Replacellcapandtightensecurely

Drive Belt    

ThedivebeltisconsideredawearableitemReplacement

intervalsdependonvehicleuseandenvironmentIfyour

beltisslippingyoumayneedtoreplaceit

1 Parkvehicleonalevelsurface,setparkbrake,place

 shifterinNeutral,turnoffignitionswitch,andremove

 switchkey

2 Removetheupperbeltcovers(Itisnotnecessaryto

 removethebottomcover

3 “Walk”thebeltoffoftherearpulleyasshowninFigure

 5-6

4 Installthenewbeltonthefrontpulleyrstand“walk”it

 ontotherearpulley

5 ReinstallthebeltguardsFigure5-7

Attention: Failure to reinstall the belt guards

may void your warranty.

gure55B

gure56

gure57

SECTION 5

maintenance

1 2 ... 15 16 17 18 19 20 21 22 23 24 25 ... 31 32

No comments

American Sportworks UTV Operations Instructions Page 20